problems with suzuki motor

yankee · 05-10-2009, 04:19 PM

ok we have checked out both the batterys we have on the boat they both check out fine and hold a charge. All the terminals on the battery are fine andwhen you go to start the boat the starter looks as if it wants to turn but it wont crank. this all started after a fishing trip in the bay and the motor started to sputter and finally conked out have a 1/2 a tank of gas in it and never had any problems like this before .we even went to the extent of checking all the fuses,wires to see if any had burnt up. im just at a loss of what to do the next step is take it too lous marine being that they are a suzuki dealer and they have worked on it beforere-doing the lower unit. Any advise we would be much thankful for.

amarcafina · 05-10-2009, 04:28 PM

Is the motor spinning fast orslow turning over?

yankee · 05-10-2009, 06:32 PM

The motor will not turn over. As I got in to the dock it stoped and would not turn over.People said it was the batery but the were o.k.IT does click but will not turn over:Really am at a loss as what to check next.

BBob · 05-10-2009, 06:35 PM

Yankee,

Did u check the fuse in the bilge next to the battery. Yes, I side in the bilge next to the battery,. BBob

DOUBLE "D" & LV · 05-10-2009, 07:42 PM

Need to break out the volt meter and see if you are loosing voltage to the starter. It could be a bad cable, end, starter, or solenoid.

amarcafina · 05-10-2009, 09:07 PM

Yeah I agree check at the starter,that should be the problem!

outbrdwrench · 05-12-2009, 01:49 AM

If you have a Load Tester, hook it up to the <U>motor</U> where the pos & neg cables attach. be sure to get a good connection & don't make sparks! If your load tester shows good batt load here, this means your batts , cables & switch are good. Remember to always tighten your batt wing nuts with pliers, even if they are clean. Good Luck!

Pinksnappertrapper · 05-12-2009, 08:06 AM

Quote:

DOUBLE "D" & LV (5/10/2009)Need to break out the volt meter and see if you are loosing voltage to the starter. It could be a bad cable, end, starter, or solenoid.

Sounds like a solenoid to me. Check the solenoid and see if its bad. If it is take it off and go to napa, orileys, and they should be able to match it.It will be a good bit cheaper that way.

Perdidoguy · 02-06-2010, 06:02 PM

I had a similar problem. It turned out to be a starter relay which is part of the Solenoid assembly. Check out http://store.brownspoint.com/microfiche.aspfor excellent exploded pictures of the engine.

Sequoiha · 02-07-2010, 08:26 AM

It sputtered and died, and would not turn over after that,,, I would grab the flywheel and make sure the engine is not locked up,,, Possibility,,,,

05-10-2009, 04:19 PM	#1
yankee Senior Member Mingo Join Date: Oct 2007 Location: fishing on the water some place Posts: 102	problems with suzuki motor ok we have checked out both the batterys we have on the boat they both check out fine and hold a charge. All the terminals on the battery are fine andwhen you go to start the boat the starter looks as if it wants to turn but it wont crank. this all started after a fishing trip in the bay and the motor started to sputter and finally conked out have a 1/2 a tank of gas in it and never had any problems like this before .we even went to the extent of checking all the fuses,wires to see if any had burnt up. im just at a loss of what to do the next step is take it too lous marine being that they are a suzuki dealer and they have worked on it beforere-doing the lower unit. Any advise we would be much thankful for.

05-10-2009, 04:28 PM	#2
amarcafina Senior Member Grouper Join Date: Aug 2008 Location: Orange Beach , Randolph AL. Posts: 746	RE: problems with suzuki motor Is the motor spinning fast orslow turning over? __________________ \ Condo in Orange Beach with Boatslip and ramp For Sale or Rent !

05-10-2009, 06:32 PM	#3
yankee Senior Member Mingo Join Date: Oct 2007 Location: fishing on the water some place Posts: 102	RE: problems with suzuki motor The motor will not turn over. As I got in to the dock it stoped and would not turn over.People said it was the batery but the were o.k.IT does click but will not turn over:Really am at a loss as what to check next.

05-10-2009, 06:35 PM	#4
BBob Senior Member Grouper Join Date: Sep 2007 Location: Jay, FL Posts: 659	RE: problems with suzuki motor Yankee, Did u check the fuse in the bilge next to the battery. Yes, I side in the bilge next to the battery,. BBob

05-10-2009, 07:42 PM	#5
DOUBLE "D" & LV Senior Member Grouper Join Date: Oct 2007 Location: pensacola Posts: 863	RE: problems with suzuki motor Need to break out the volt meter and see if you are loosing voltage to the starter. It could be a bad cable, end, starter, or solenoid.

05-10-2009, 09:07 PM	#6
amarcafina Senior Member Grouper Join Date: Aug 2008 Location: Orange Beach , Randolph AL. Posts: 746	RE: problems with suzuki motor Yeah I agree check at the starter,that should be the problem! __________________ \ Condo in Orange Beach with Boatslip and ramp For Sale or Rent !

05-12-2009, 01:49 AM	#7
outbrdwrench Member Ruby Red Lip Join Date: Apr 2009 Location: Pace, Florida Posts: 98	RE: problems with suzuki motor If you have a Load Tester, hook it up to the <U>motor</U> where the pos & neg cables attach. be sure to get a good connection & don't make sparks! If your load tester shows good batt load here, this means your batts , cables & switch are good. Remember to always tighten your batt wing nuts with pliers, even if they are clean. Good Luck!

02-06-2010, 06:02 PM	#9
Perdidoguy Junior Member Cigar Minnow Join Date: Aug 2009 Posts: 2	RE: problems with suzuki motor I had a similar problem. It turned out to be a starter relay which is part of the Solenoid assembly. Check out http://store.brownspoint.com/microfiche.aspfor excellent exploded pictures of the engine.

02-07-2010, 08:26 AM	#10
Sequoiha Senior Member Sailfish Join Date: Sep 2007 Location: Pensacola Florida Posts: 2,477	RE: problems with suzuki motor It sputtered and died, and would not turn over after that,,, I would grab the flywheel and make sure the engine is not locked up,,, Possibility,,,, __________________ Kenny Mann Ms Penny Fishing Team Member NRA 172499461 Minn Kota ASC Dealer for The Super Stick www.thesuperstick.com Emerald Coast Marine LLC Allmost Anything Computers 4610 Saufley Field Rd Pensacola Fl, 32526 1-850-456-8196 1-850-455-8318 Sequoiha@cox.net Kenny_Mann-ECM@cox.net

Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)

Thread Tools
Show Printable Version Email this Page
Display Modes
Linear Mode Switch to Hybrid Mode Switch to Threaded Mode